UNION OIL CO OF CALIFORNIA -- 05455, UNOCAL UNOBA EP GREASE 2  -- 9150-00-426-8090
<pre>=====================  Product Identification  =====================

Product ID:05455, UNOCAL UNOBA EP GREASE 2
MSDS Date:06/21/1990
FSC:9150
NIIN:00-426-8090
=== Responsible Party ===
Company Name:UNION OIL CO OF CALIFORNIA
Address:1201 WEST 5TH STREET
City:LOS ANGELES
State:CA
ZIP:90017
Country:US
Info Phone Num:213-977-7589
Emergency Phone Num:800-356-3129;800-424-9300(CHEMTREC)
CAGE:79003
=== Contractor Identification ===
Company Name:UNION OIL CO OF CA UNION 76 DIV- WESTERN RGION
Address:1201 W 5TH ST
Box:7600
City:LOS ANGELES
State:CA
ZIP:90017-1443
Country:US
CAGE:79003

=============  Composition/Information on Ingredients  =============

Ingred Name:MINERAL OIL: (SPENT LUBE OIL, CLAY TREATED)
CAS:64742-50-3
Fraction by Wt: 37-40%
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3;10STEL(MIST)

Ingred Name:SOLVENT REFINED RESIDUUM
CAS:64742-01-4
Fraction by Wt: 32-35%
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3;10STEL(MIST)

Ingred Name:MINERAL OIL, PETROLEUM DISTILLATES,HYDROTREATED HEAVY
    NAPHTHENIC
CAS:64742-52-5
RTECS #:PY8035000
Fraction by Wt: 12-15%
OSHA PEL:5 MG/M3 (OIL MIST)
ACGIH TLV:5 MG/M3;10STEL(MIST)

Ingred Name:TRADE SECRET COMPONENT
Other REC Limits:NONE SPECIFIED

Ingred Name:SUPP DATA: IS DROWSY/UNCON, PLACE ON LEFT SIDE W/HEAT DOWN.
    DO NOT GIVE ANYTHING BY MOUTH. IF POSS, DO NOT LEAVE (ING 6)
RTECS #:9999999ZZ

Ingred Name:ING 5: VICTIM UNATTENDED. COMMENTS: HIGH PRESS GREASE GUN
    INJURIES MAY PRDCE SUBSTANTIAL NECROSIS OF UNDERLYING (ING 7)
RTECS #:9999999ZZ

Ingred Name:ING 6: TISSUE DESPITE AN INNOCUOS APPEARING EXTERNAL WOUND.
    OFTEN THESE INJURIES REQ EXTENSIVE EMERG SURGICAL (ING 8)
RTECS #:9999999ZZ

Ingred Name:ING 7: DEBRIDEMENT & ALL INJURIES SHLD BE EVALUATED BY A
    SPECIALIST IN ORDER TO ASSESS EXTENT OF INJURY.
RTECS #:9999999ZZ

Ingred Name:SPILL PROC:RESP PROT AS CNDTNS WARRANT. PVNT SPILLED MATL
    FROM ENTERING SEWERS, STORM DRAINS, OTHER UNAUTHORIZED(ING 10)
RTECS #:9999999ZZ

Ingred Name:ING 9: TREATMENT/DRAINAGE SYSTEMS & NATURAL WATERWAYS.
    NOTIFY APPROP FEDERAL, STATE & LOCAL AGENCIES. CLEANUP (ING 11)
RTECS #:9999999ZZ

Ingred Name:ING 10: UNDER SUPERVISION IS ADVISED. IF SPILL OF ANY AMT
    IS MADE INTO/UPON U.S. NAVIGABLE WATERS, CONTIGUOUS (ING 12)
RTECS #:9999999ZZ

Ingred Name:ING 11: ZONE OR ADJOINING SHORELINES, NOTIFY NATIONAL
    RESPONSE CENTER (PHONE #800-424-8802).
RTECS #:9999999ZZ

Ingred Name:OTHER PRECS: EXPOS LMTS. DO NOT WEAR CONTAMD CLTHG/SHOES.
    USE GOOD PERS HYGIENE PRACT. "EMPTY" CNTNRS RETAIN (ING 14)
RTECS #:9999999ZZ

Ingred Name:ING 13: RESIDUE (LIQ &/VAP) & CAN BE DANGEROUS. DO NOT
    PRESS, CUT, WELD, BRAZE, SOLDER, DRILL, GRIND/EXPOS SUCH (ING 15)
RTECS #:9999999ZZ

Ingred Name:ING 14: CNTNRS TO HEAT, FLAME, SPARKS/OTHER SOURCES OF
    IGNIT, THEY MAY EXPLODE & CAUSE INJURY/DEATH. "EMPTY" (ING 16)
RTECS #:9999999ZZ

Ingred Name:ING 15: DRUMS SHLD BE COMPLETELY DRAINED PROPERLY BUNGED &
    PROMPTLY SHIPPED TO SUPPLIER/A DRUM RECNDTNR. ALL (ING 17)
RTECS #:9999999ZZ

Ingred Name:ING 16: OTHER CNTNRS SHLD BE DISP OF IN AN ENVIRON SAFE
    MANNER & I/A/W GOVERNMENTAL REGS. BEFORE WORKING ON/IN (ING 18)
RTECS #:9999999ZZ

Ingred Name:ING 17: TANKS WHICH CONTAIN/HAVE CONTAINED PROD, REFER TO
    OSHA ADMIN REGS, ANSI Z49.1 & OTHER GOVERNMENTAL & (ING 19)
RTECS #:9999999ZZ

Ingred Name:ING 18: INDUSTRIAL REFERENCES PERTAINING TO CLEANING,
    REPAIRING, WELDING/OTHER CONTEMPLATED OPERATIONS.
RTECS #:9999999ZZ

Ingred Name:VENT: SYSTEMS MAY BE REQD. WHERE EXPLOS MIX MAY BE PRESENT,
    ELECT SYSTEMS SAFE FOR SUCH LOCATIONS MUST BE USED.
RTECS #:9999999ZZ

Ingred Name:FIRE FIGHT PROC:DONE W/OUT RISK.H*2O SPRAY MAY BE USEFUL IN
    DISPERSING VAPORS AND COOLING EQUIP EXPOSED TO HEAT & FLAME.
RTECS #:9999999ZZ

=====================  Hazards Identification  =====================

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES  Skin:NO  Ingestion:YES
Reports of Carcinogenicity:NTP:NO    IARC:NO	OSHA:NO
Health Hazards Acute and Chronic:EYES: MATL MAY CAUSE MILD EYE IRRIT.
    DIRECT CONT W/LIQ/EXPOS TO VAPS/MISTS MAY CAUSE STINGING, TEARING &
    REDNESS. SKIN: MATL MAY CAUSE MILD SKIN IRRIT. PRLNGD/RPTD CONT MAY
    CAUSE REDNESS, BURNING, & D RYING & CRACKING OF SKIN. NO HARMFUL
    EFTS ARE EXPECTED FROM SKIN ABSORP OF MATL. INHAL: UNLIKELY. (EFTS
    OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: INGEST: WHILE THIS MATL HAS A LOW
    DEGREE OF TOX, INGEST OF EXCESSIVE QTYS MAY CAUSE IRRIT OF
    DIGESTIVE TRACT. HIGH PRESSURE GREASE GUN INJURY CAN CAUSE SERIOUS
    DELAYED SOFT TISSUE DAMAGE.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
    DISORDERS MAY BE MORE SUSCEPTIBLE TO THE EFFECTS OF THIS MATERIAL.

=======================  First Aid Measures  =======================

First Aid:EYES: MOVE VICTIM AWAY FROM EXPOS & INTO FRESH AIR. FLUSH
    EYES W/CLEAN WATER. IF SYMPS PERSIST, SEEK MED ATTN. SKIN: WIPE
    MATL FROM SKIN & REMOVE CONTAMD SHOES & CLTHG. CLEANSE AFFECTED
    AREA(S) THOROU GHLY BY WASHING W/MILD SOAP & WATER & IF NEC, A
    WATERLESS SKIN CLEANSER. IF IRRIT/REDNESS DEVELS & PERSISTS, SEEK
    MED ATTN INHAL: SINCE VAP PRESS IS LOW, VAP INHAL UNDER AMBIENT
    CNDTNS IS(SUPP DATA)

=====================  Fire Fighting Measures  =====================

Flash Point Method:COC
Flash Point:420F,216C
Extinguishing Media:DRY CHEMICAL, FOAM, WATER OR SAND IS RECOMMENDED.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP
    . STOP SPILL/RELEASE IF IT CAN BE DONE W/OUT RISK. MOVE UNDMGD
    CNTNRS FROM FIRE AREA IF IT CAN BE(ING 21)
Unusual Fire/Explosion Hazard:THIS MATERIAL MAY BURN, BUT WILL NOT
    IGNITE READILY.

==================  Accidental Release Measures  ==================

Spill Release Procedures:MAY IGNITE. KEEP ALL SOURCES OF IGNIT AWAY
    FROM SPILL/RELEASE. STAY UPWIND & AWAY FROM SPILL/RELEASE. ISOLATE
    HAZ AREA & LMT ENTRY TO AUTH PERS. STOP SPILL/RELEASE IF IT CAN BE
    DONE W/OUT RISK. WEAR A PPROP PROT EQUIP INCL NIOSH/MSHA APPRVD(ING
    9)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

======================	Handling and Storage  ======================

Handling and Storage Precautions:USE & STORE THIS MATL IN COOL, DRY,
    WELL VENT AREAS AWAY FROM HEAT & ALL SOURCES OF IGNIT. KEEP CNTNRS
    CLSD. STORE ONLY IN APPRVD CNTNRS.
Other Precautions:KEEP AWAY FROM AN INCOMPAT MATLS. PROT CNTNRS AGAINST
    PHY DMG. DO NOT ENTER CONFINED SPACES SUCH AS PITS/TANKS W/OUT
    FOLLOWING ENTRY PRCDRS SUCH AS ASTM D-4276. USE OF NIOSH/MSHA PRES
    PROT IS ADVISED  WHEN CONC EXCEED ANY ESTABLISHED(ING 13)

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:NIOSH/MSHA RESPIRATORY PROT IS ADVISED WHEN CONC
    EXCEED ESTABLISHED EXPOS LMTS. DEPENDING ON AIRBORNE CONC, USE A
    NIOSH/MSHA APPRVD RESP/GAS MASK W/APPROP CARTRIDGES & CANNISTERS
    (NIOSH/MSHA) OR SUPPL IED AIR EQUIPMENT.
Ventilation:IF CURRENT VENT PRACT ARE NOT ADEQ TO MAINTAIN AIRBORNE
    CONC <ESTABLISHED EXPOS LMTS, ADDITIONAL VENT/EXHST (ING 20)
Protective Gloves:IMPERMEABLE GLOVES.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:A SOURCE OF CLEAN WATER SHLD BE AVAIL IN
    WORK AREA FOR FLUSHING EYES/SKIN. IMPERVIOUS CLTHG SHLD BE WORN AS
    NEEDED.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRST AID PROC: UNLIKELY. IF OVERCOME BY VAP FROM HOT PROD, MOVE VICTIM
    AWAY FROM SOURCE OF EXPOS & INTO FRESH AIR. IF IRRIT PERSISTS, SEEK
    MED ATTN IF VICTIM IS NOT BRTHG, ARTF RESP SHLD BE ADMIN. IF  BRTHG
    DFCLTS DEVEL, O*2 SHLD BE ADMIN BY QUALIFIED PERS. SEEK IMMED MED
    ATTN. INGEST: SEEK MED ATTN. IF VICITM (ING 5)

==================  Physical/Chemical Properties  ==================

Boiling Pt:B.P. Text:>600F,>316C
Vapor Density:>1
Spec Gravity:0.86 
Evaporation Rate &amp; Reference:<1 (N-BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GREEN BUTTERY GREASE W/CHARACTERISTIC PETROLEUM
    ODOR.
Percent Volatiles by Volume:NEG

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:EXTENDED EXPOSURE TO HIGH TEMPERATURES MAY
    CAUSE DECOMPOSITION.
Hazardous Decomposition Products:COMBUSTION MAY YIELD MAJOR AMTS OF
    CO*X, & MINOR AMTS OF SO*X & NO*X.

====================  Disposal Considerations  ====================

Waste Disposal Methods:DISPOSE OF PRODUCT IN ACCORDANCE WITH LOCAL,
    COUNTY, STATE, AND FEDERAL REGULATIONS.

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.